山谷型磷石膏渣场酸性工艺水渗漏分析

我国大多数磷石膏渣场建于山谷之中,并以黏土底垫层作为防渗层。通过建立针对典型山谷型磷石膏渣场的渗流模型,使用二维有限元渗流分析方法对山谷型磷石膏渣场酸性工艺水的渗漏模式和渗漏量进行了分析。分析表明:山谷型磷石膏渣场酸性工艺水渗漏量不仅和黏土防渗层的垂直渗透系数有关,而且与黏土防渗层下部风化岩层的水平渗透性相关。如水平渗透性较大,黏土防渗层对阻止酸性工艺水流失的作用有限。分析还表明,由于谷口垂直防渗帷幕不大可能封堵住所有风化岩层中的裂隙,很难阻止渗过黏土防渗层的酸性工艺水向渣场外渗漏。     

新型环保节能烟囱的技术特征和运行原理

提出了一种新型烟囱技术,即利用旋涡流动的空气动力学特点,妥善地解决了湿法脱硫后烟囱内壁的腐蚀问题.同时,新型烟囱还具有更好的节能、环保效果.系统地论述了新型烟囱技术的基本内涵、主要技术优势、设计要点与运行原理,从空气动力学原理和工程实践两方面说明新型烟囱技术的合理性与实践可行性.     

利用单颗粒气溶胶质谱仪研究燃煤尘质谱特征

采用单颗粒气溶胶质谱仪(SPAMS)和再悬浮采样器联用的方式对燃煤电厂烟道气样品和下载灰样品的质谱特征进行测定,并使用颗粒物粒径分级采样仪ELPI测定其粒径分布特征.研究表明,SPAMS监测得到的粒径分布与ELPI结果差异较大,SPAMS对于500 nm以上粒径段检测效果较好;两个样品正谱图中有非常明显的锂、钙、钛、铝等金属组分信号和碳组分信号特征,负谱图中硅酸盐、硝酸盐和硫酸盐等信号比较明显,并且随着粒径的增加碳组分、硫酸盐和硝酸盐等组分对应的信号强度逐渐减弱,而硅酸盐、铝、钙和钛等组分对应的信号强度逐渐增强;对两个样品使用ART-2a聚类获得多个颗粒物类别,分析表明,它们均含有元素碳二次类(硫酸盐和硝酸盐缩写为二次Sec)、有机碳二次类、铝元素碳类、铝钙硅酸盐类和富硅酸盐类等颗粒物类别,并且随着粒径的增加金属硅酸盐颗粒出现频率增大,而含碳颗粒与硫酸盐出现频率降低.但烟道气样品和下载灰样品的质谱特征呈显著差异,下载灰样品更能代表燃煤源真实排放特征.建议在今后建立基于单颗粒质谱固定源成分谱时,应使用单颗粒气溶胶质谱仪在外场进行实测,并使用聚类的方法提取不同粒径段上的源质谱特征,可能会取得更好的效果.     

火电厂湿烟囱排放的可行性探讨

在石灰／石灰石-石膏法湿法烟气脱硫（FGD）工艺中,是否安装烟气热交换器（GGH）的问题一直受到关注。本文介绍了湿法烟气脱硫工艺中GGH的作用,设置GGH的弊端,以及湿烟囱排放对工艺和设备所提出的更高的设计要求。从安全和经济角度考虑,对于FGD工艺采用湿烟囱排放代替GGH是可行的。     

Laboratory-scale study of the suppression of PCDD/F emission during coal and MSW co-incineration

The experimental test of co-incinerating Chinese raw municipal solid waste （MSW） and coal in a laboratory-scale tubular reactor was first reported in present study, and the emission of normal gas components and the effects of the S/Cl molar ratio or coal mixing percentages on polychlorinated dibenzo-p-dioxins and dibenzofurans （PCDDs/Fs） emission were investigated and discussed. The results indicated that OCDD was the only PCDD homologues since others like TCDD-HpCDD was hardly detected, while as the categories of PCDF homologues were comparatively much more general. The amount of PCDD was much larger than that of PCDF in all operating conditions. Since ZPCDF/∑PCDD〈〈1, the dominant role of the precursor formation was proven in our experimental conductions. With increasing the coal addition to MSW （from 0 to 16%）, PCDD and PCDF were reduced considerably. Coal and MSW may suppress the PCDD/F emissions efficiently （over 95%） during the MSW incineration process. The PCDD/F suppression results of the present study could be helpful guidance to the industrial application of Chinese MSW and auxiliary coal co-incineration processes. The PCDD/F stack emission data of two industrial incinerators using co-incineration technology in China seem to have a great positive reduction of PCDDs/Fs.     

未脱水污泥中铅的电动力去除

以城市污水处理厂二次沉淀池未脱水污泥为研究对象,在自制的三槽型电解槽中采用电动力学法去除污泥中的铅.对实验过程中的污泥pH、电导率变化进行分析讨论.研究污泥消化、电动力处理时间、搅拌、阴极室电解液pH,对电动力学法除铅的影响.实验发现:污泥消化不利于电动力法对污泥中铅的去除;延长电动力处理时间可不同程度地提高污泥中铅的...     

多氯联苯焚烧处置时烟灰中的二噁瑛

专门用于销毁含多氯联苯（ＰＣＢｓ）固体废弃物的中试焚烧炉,焚烧排放物中含有微量剧毒二（ＰＣＤＤ／ＦＳ）．应用同位素稀释ＨＲＧＣ／ＨＲＭＳ方法测定了烟灰中的ＰＣＤＤ／Ｆｓ含量,以１７种有毒同族体的含量可计算出样品的２,３,７,８－ＴＣＤＤ毒性当量为４７．２ｎｇ／ｇ。     

火炬气回收及排放系统的优化

阐述了洛阳石化总厂火炬气排放及回收系统的优化改造措施，评价了在降低生产成本及环境保护等方面的效果。     

水泥机立窑窑尾烟气水雾喷淋除尘治理技术

机立窑窑尾烟气因含尘浓度高,温度、湿度变化大等原因,治理的难度较大,很多厂家均采用沉降室来治理窑尾烟气,但效果都不够理想.而铜山县第九水泥厂采用了水雾喷淋除尘技术治理窑尾烟气,从一段时间的运行状况看,取得了明显的成效.     

A new approach for biological online testing of stack gas condensate from municipal waste incinerators

A biological testing system for the monitoring of stack gas condensates of municipal waste incinerators has been developed using Euglena gracilis as a test organism. The motility, velocity and cellular form of the organisms were the endpoints, calculated by an image analysis system. All endpoints showed statistically significant changes in a short time when organisms were exposed to samples collected during combustion situations with increased pollutant concentrations. The velocity of the organisms proved to be the most appropriate endpoint. A semi-continuous system with E. gracilis for monitoring stack gas condensate is proposed, which could result in an online system for testing stack gas condensates in the future.